Search results

  1. Dukedog

    Mercury 2.5 liter interchangeability

    yeah.. thats a lot later model.. '95 or better.. think '94 and older had exhaust slots where that one has anodes....
  2. Dukedog

    Mercury 2.5 liter interchangeability

    can't tell from that angle.. pre-load has a "pin" stickin' outta tha top of tha driveshaft.. can't see either slots or anode right above tha cav plate either.. 4 hole inlet is on small dia. XR4/6 case only..
  3. Dukedog

    Mercury 2.5 liter interchangeability

    justa 'bout all 2.0, 2.4, 2.5 are interchangeable with a few things that need ta be done in some instances.. knowing what comes witha lotta experience 'cause there isn't any thing published ta tell ya what goes with what... that gear case is ok for a spare but its whats called a "pre-load...
  4. Dukedog

    Mercury 2.5 liter interchangeability

    get yaself a new power head gasket (for either one, xr6 or efi) and get after it..... justa a reminder.. be sure ta disconnect (one 7/16's nut) the "sliding" part of tha shift linkage at tha anchor bracket before ya pull tha ph!..
  5. Dukedog

    Over heating problem. need help

    callin' computer "calf rope" with this problem!
  6. Dukedog

    Over heating problem. need help

    jus sounds like it has something ta do with tha poppit???.. did ya check tha "staked" bushing in tha block.. its not supposed ta rotate at all.
  7. Dukedog

    Over heating problem. need help

    sometimes in tha poppet tha plastic disc will get slightly "warped".. you will not notice it unless ya lookin' for it.. we built our own from alum. stock ta replace tha plastic.. that can cause what your experiencing.. if ya put new parts in it maybe that was it???
  8. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    found an *.. looks like tha 4 stroke starts at 1B905505..
  9. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    strange.. first time entered serial number on Merc's web site came up as 2011 4 cyl. 4 stroke.. now it says number not found???
  10. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    order ya parts by your serial number and see what ya get!
  11. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    there's a lotta numbers "after" tha 1B.. ya gotta take tha whole number ya have and not worry 'bout tha "range"...............................
  12. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    shows up in parts as 2010..... 2011 is a 4 cylinder 4 stroke.. could be either 2010 or 2011 depending on quarter it was built??? whats really strange is both model and serial number shows up as a 4 cyl. 4 stroke on brunswick (Merc) parts site???
  13. Dukedog

    outboard was very hard to start after sitting a while then smoked a lot

    tha heavy smoke indicates its gettin way more fuel than needed for whatever rpm its tryin' ta run and/or not firin' properly.. may be time for injector and injector o-ring service... don't know where ya are and/or what type fuel ya get in that location but fuel lines may need a close check...
  14. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    depending on year it may or may not have a fuel filter on tha bottom of tha electric pump that ya might as well change also....
  15. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    (y)
  16. Dukedog

    Merc's 150 HP 2 Stroke EFI Motor.-

    year?
  17. Dukedog

    Tilt and trim help

    yes sir!.. man o man.. thats quite a few "coffee stains" back.. :) most first gen and earlier stuff is really startin' ta fade away along with a lot of other things... still beats tha alternative though!!!
  18. Dukedog

    Tilt and trim help

    don't remember ever seein' a tilt/trim circuit being wired inta tha key switch for power.. at least not factory..???
  19. Dukedog

    Mercury 150 Black Max ~1992 year model

    are you absolutely sure tha transom, stringers and floor are still solid???
  20. Dukedog

    Mercury 150 Black Max ~1992 year model

    ............
Top