Search results

  1. B

    Fuel

    Check and make sure the fuel cell cooling lines are flowing properly. They can get clogged which can result in pumps overheating.
  2. B

    NEED A VP PROS OPPINION!

    400 hours is not all that much. I would plan on changing the oils and filters if not done recently. Maybe plan on doing the distributor caps, rotors, plugs and wires sometime in the near future to create a maintenance baseline going forward. Also change the drive oil, if not done recently. No...
  3. B

    Lower Unit Gear Oil Change while on lift

    Can you borrow a jon boat to float under the drive. It isn`t going to be easy but I guess it could be done.
  4. B

    NEED A VP PROS OPPINION!

    How many hours are on the engines? They are generally good engines and drives. It will all depend on how they were maintained. How old are the exhaust manifolds? You might plan on replacing them in the near future if not replaced recently.
  5. B

    Remove One Exhaust Bolt - Need to redo all bolts with new gasket?

    I would think that you would be ok removing and reinstalling the bolt. The only thing I see you risking is shearing off the bolt and then having to remove the entire manifold.
  6. B

    Engine shutdown procedure VP 8.1 Gi-J

    I think you are overthinking the situation. Water ingestion is not that common and unless someone has modified your exhaust system, I would not worry about it. I would advise not to come to a sudden stop after traveling at speed to avoid a high backwash against the transom.
  7. B

    Outdrive Pressure test Question

    If I remember right, there are several Youtube video`s online to reference before starting the task.
  8. B

    Eng acts like safety kill switch is engaged.

    Had a similar issue a few years back, turned out to be a bad crank shaft position sensor.
  9. B

    2003 Chris Craft Launch 25 - VolvoPenta engine replacement - need engine advice

    I don't know that I would plan to spend 20K on a new engine and drive on a 2003 boat regardless of its condition. it will not add that to the value of the boat. I would put a re-man engine 5.7 back in it and pocket the balance. Your torque problems could be solved by changing the prop(s).
  10. B

    Volvo Penta Fuel Pump Whining Noise

    If indeed the high pressure pump is bad, there are many more remedies today than a few years ago. You can replace the entire unit with an aftermarket one for a couple hundred bucks or you can purchase just the high pressure pump and install it for cheap too. If you keep the origional unit, I...
  11. B

    My stern drive oil is black

    Could be the wrong type of oil, very old oil or burnt oil from overheating. Change it regardless and I`d pull the drive for an overall inspection and service.
  12. B

    Exhaust Riser?

    Are you getting any overheating alarms? Do the risers feel hot to touch? If not, the stoppage in running is probably not related to the manifold/risers.
  13. B

    Exhaust riser temperatures

    I`d suggest you start by removing the thermostat housing and thoroughly cleaning out the internal passages. There are a few that can be hard to find if you do not know where to look.
  14. B

    Seeking advice regarding Volvo Penta 5.7GXi-HF fuel pump whine

    For what little they cost, I would probably try one of those $200 aftermarket pump assemblies to see if the whine persists. Worst case scenario is now you have a back up pump.
  15. B

    Oil leak - Volvo Penta 5.7

    I think we need more specific information on what model of engine and the hours on that engine.
  16. B

    Updated Manual Link?

    I found my engine and drive manual on ebay. Might look there.
  17. B

    OMC vs Volvo drives

    No need to fear Volvo drives. I`ve had two and both were very well built and very durable. Obviously maintenance is a must on any drive.
  18. B

    DPS Lower Water Leak and Prop Shaft Play

    I purchased my outdrive manual on ebay.
  19. B

    Engine Trolley Stand

    I purchased on of Stumpy`s stands after using a home made for years. The Stumpy`s is much nicer in that you can adjust the height of the stand much easier. If you plan on using it often. I suggest Stumpy`s.
  20. B

    Drive destroyed

    Would like to know specifically more about the damage. Is the gearcase ruptured or just some bent props. Got a pic? Maybe you just need a new lower and not the entire drive.
Top