Search results

  1. yzf125

    Melted Stator wires ?

    Hey guys, I have a 2002 Mercury 75 hp 2 stroke, I noticed the 2 wires that come from that stator have melted the shields where they connect. What would cause this ? Everything works as it should and charges fine.
  2. yzf125

    Main engine fuse blown while sitting ?

    Hey guys, My boat has been stored in the garage for the winter, it has a 2002 Mercury 75hp ELPTO. I have done nothing but charge the batteries every month, I went to raise the motor the other day and nothing worked so I checked the fuse on the motor and noticed the Main engine fuse "20 amp" had...
  3. yzf125

    Difference between Carburetor models ??

    Hey guys I have a question about all the different cab models For my 2002 75hp # 0T564442 ELPTO. First off, why is there 5 different carbs for my engine model year, and what are the differences, The only thing I can think of is the Main Jets ?? It shows 5 different 75hp model carbs WME-82...
  4. yzf125

    Water coming from Exhaust cover Plate bolt ?

    Hey guys, I have water dripping from one of my exhaust cover plate bolts, I check tightness and they are all tight ? Does this mean the gasket needs to be replaced ?
  5. yzf125

    What would cause this ??

    Hey guys, What would cause these wires going to the voltage regulator to melt together ?? and would this cause any issues other than the charging circuit ?? ( Motor in my sig ) I ask because I still have an ongoing problem with anything past 4k I get what feels like a rev limiter kicking in...
  6. yzf125

    Weird thing Happened....

    Hey guys, I was chasing an ongoing problem with my motor and decided to throw some parts at it instead of spending the big bucks at the stealership 100 per hour !!!! So I proceeded to replace my trigger on my 75hp mercury, When I was removing the screws that hold the stator to the motor each one...
  7. yzf125

    Timing Question ?

    Hey guys, I wanted to check timing on my 02 Mercury 75hp 2 stroke. Now the sticker on the side of the motor says " 2 BTDC / 18 BTDC " I am assuming this is @ cranking settings ? So I checked and came up with Idle cranking at 5 and WOT at 20, Is this ok ?
  8. yzf125

    Zapped by my ignition switch ??

    Hey guys, I was just cruising down a channel with my boat and noticed the ignition switch was turned a little too far to the left as it must have loosened up a little, so I grabbed the back of it as I was driving to hold it as I tighten the nut on the front and I got zapped from the wire...
  9. yzf125

    How to test a CDM module ?

    Hey guys, I am having an issue that Im starting to think could be ignition related and would like to know how to test a CDM module (coil pack) on my 2002 Mercury 75hp. It may be cutting in and out after half throttle that I am noticing, originally thought it was fuel related but I have done...
  10. yzf125

    2002 Mercury 75hp WOT Surge

    Hey guys, I have an issue with my 2002 Mercury 75hp elpto. When wide open throttle it just seems to fall flat and surges a bit, If I back off to about 3/4 or 1/2 it seems fine. Runs good out of the hole, I can just mash it and it takes right off with NO hesitation, Its only WOT that I have any...
  11. yzf125

    2002 Mercury 75hp ELPTO Float Height ??

    Hey guys, Im going to pull my carbs apart and clean them on my 2002 Mercury 75hp ELPTO 2 stroke, Does anyone know the correct float height for this ? Also what is the fuel screw setting ? Thanks
  12. yzf125

    Fish Finder That reads while driving ?

    Re: Fish Finder That reads while driving ? Ok here are a few more pics.
  13. yzf125

    Fish Finder That reads while driving ?

    Hey guys, Any recommendations on a low cost fish finder that will read as your driving ? Nothing to fast just up to 20 mph or so. I have a older Humminbird 200 dx now that does not read anything over 5 mph !! Im not looking for anything special just a basic finder will do, long as it will read...
  14. yzf125

    Touch up paint Lowe Stinger ?

    Hey guys, Where can I get touch up paint for my 2002 Lowe Stinger 160 , Its a navy blue color. Or Anyone know the correct duplicolor touch up # that would match ? Thanks !
  15. yzf125

    Power tilt / trim 1990 Evinrude 50 HP

    Hey guys, I am looking on Ebay for a power tilt / trim for my 1990 Evinrude 50 hp. what years and what HP will work with my motor. Thanks for any help
  16. yzf125

    1990 evinrude 50hp can i make it power tilt ?

    Hey guys, I have a 1990 evinrude 50hp Model VE50BELESR On a 1991 17' Sea Nymph I dont have power tilt and want to install it. What do i need to do this Thanks for any help Guys!
Top