Search results

  1. D

    140 Johnson temp light

    When I start the boat, the temp light comes but it is very faint. Runs fine and is not in cripple mode or anything. Clean the battery post and still doesn't work seems very weird. Engine is pissing just fine and isn't running hot. Any ideas?
  2. D

    Johnson Tach replacement

    Need some help to see if anybody has done this before. My tach is old and very worn to the point where you can't see it. I need a new one but didn't have the money. I got a free set from a friend who works for a Suzuki dealer. I thought it would be pretty easy since my motor is pretty much a...
  3. D

    Advice, Help, sick to my stomach!!!

    Well I don't come on here much but after today, I need some help. I have a 2003 140hp johnson and it felt like it needed to stop running today in the middle of a inlet with out any warning from the engine at all. It was going just find, then it just cut off and mid throttle. I had no power to...
  4. D

    Oh man I messed up, 24 volt trolling motor

    Guys I need some help. Well I took off the two bolts and pulled the armture off a little bit to clean the inside. Well I pulled it out to far and now it slipped out of the brushes. I have no clue how to get the armture housing off to get to the brushings so I can reset them. Any advice?
  5. D

    Removal of carbon in exhaust

    I am thinking I have a large about of carbon build up in my engine causing exhaust back pressure making the engine bog down at lower RPM. My question what is the best way to go about this? It is a 2003 4 stoke engine. Should I get a small gas tank and run a large amount of cleaner throught...
  6. D

    Suzuki / Johnson 140 check engine light

    Moving this over here from the Johnson form because of this almost being a suzuki engine. It is a 2003 140hp johnson. I am about to go crazy with this check engine light. I get the check engine light ONLY when in the water after about idling for about 3 min. Its a 3-2 blink which I...
  7. D

    Map sensor 2 fault 140 johnson

    The manual says " Cause by disconnected, kinked or clogged MAP sensor house or clogged inlet manifold gas filter." Seems easy to check but yet I can't find this hose they are taking about. Is it behind the mainfold where I can't see it? I seen the map sensor where it goes into the mainfold...
  8. D

    03 Johnson 140 check engine light

    Hello all, Hoping you guys and gals could help me out. I have a 03 140 Johnson that has worked great. The other day I went out, it was a little ruff out in the water but I ran about a mile down at full speed and then stopped and started to get the boat ready to set the anchor when the check...
Top