Search results

  1. rcl700

    How to test / check a Tachometer? 60hp Mariner

    I recently replaced the switch box on and this solved a bunch of problems I was having. Im now up and running. But now I have another issue. The tachometer is no longer working. The ring light works but I have no RPM reading. The back of the tach. has three wires, black, purple, and gray in the...
  2. rcl700

    wire rot (can I rewire)?

    I have a 1984 Mariner 60hp 3cyl. Im having issues with the electrical parts on the motor. Most of the wires have rotted coming from the stator and the trigger. I want to know, if I pull the fly wheel off can I cut the wires and solder on some new ones?(make my own wiring harness) I was able...
  3. rcl700

    water in the pontoon logs / finding leaks

    I have found that both of my pontoon logs are filling with water when I get home from a trip I remove the lower plugs from the tubes to get it out. My question is how can I find where the water is getting in? I was thinking of using my compressor but I dont want to blow up my pontoons with to...
  4. rcl700

    TLDI air pump cost

    I have my motor in the shop. I was told today that I need to replace the air pump. Fuel and air psi are around 50 psi. Need to be at 80 & 90 PSI I being told the cost for the pump is $680. :eek: is there a better cost for this part out there? 2004 90B TLDI. Tohatsu.
  5. rcl700

    Underskining toon ?

    Anyone see any other material other than sheet aluminum to underskin a toon? I was looking at some glass board sheets at lowes today and they look like they would do the job & an cost alot less. 4' x8' Frp fiber board. .090 thick. Seem strong, water proof, mold proof, cheep $26 a sheet...
  6. rcl700

    Treated wood ok?

    Is pressure treated 3/4 ply doubled up ok to make a new transom board out of ? Mine is still ok but I'd like to make one so it will be ready when I need it. My boat makes about 15 trips a year to the lake. 8hr max each time.
  7. rcl700

    I tested my new prop. where should I go now?

    I took my pontoon out for a test run yesterday. I had issues. I had a new prop (Turning point Hustler 15p 13-3/4'') on the motor after rebuilding the lower unit. I think I picked the wrong prop . My max RPM was 4500 and I need 5500. I did get 26.6 MPH from my gps unit think I need togo from...
  8. rcl700

    Rear tie down placement

    I have a pontoon with.a lift trailer. I'm looking for a good place to put rear tie downs on. I don't want to hook to the transom because it is just hanging by a few bolts an it already has the weight of the motor hanging on it. Should I hook a rachet strap to the underside of the deck? Will be...
  9. rcl700

    Fold out table

    Is anyone using a fold out table on there pontoon? I was thinking of making one hinged off the fencing. Just wondered if this was being done and if not why. I thought it may keep it out of the way when it is in the down position.
  10. rcl700

    cheep LED nav lights

    Found these LED lights on ebay they are cm flexible light strips they have 3M backing on the so its a very easy install. I used them for my navigation light on my pontoon. They seem to work great.
  11. rcl700

    will this work?

    I'm trying to set up my batteries in my boat. below is a pic of a setup. Can you take a look and see if this will work? hear is a link to the kind of switch I illustrated in the picture. Dual Circuit Plus? Battery Switch...
  12. rcl700

    Tldi no start

    Well I just finished rebuilding lower unit and placed the motor on the transom of my pontoon. Hooked everything up ( fuel,batt.,tac. ) new 12 gal fuel tank and new gas from the station that day. Battery fully charged new plugs (autolite) Turned the key first time > fired up and ran for about...
  13. rcl700

    trim gauge for TLDI

    Does Iboats have a trim gauge that will work for a Tohatsu TLDI motor? If so how are these wired in?
  14. rcl700

    TLDI battery

    I have looked at the tohatsu web page and it recomends the following Do I need a special battery to start a TLDI?? Because of the additional power requirements needed for a direct injection, TLDI? motors require you to use a marine battery with the following rating: 850 Cold Cranking Amps...
  15. rcl700

    gas can on boat (safe)

    is it safe to carry an extra gas can (5gal.) on the boat? maybe even one of those metal military cans? If I go out on a big lake or plan on camping.
  16. rcl700

    top side tank

    Im going to install a 12 gal. top side fuel tank on my toon. does this or should this tank be removed when filling it? I see removal being recomended for the portable tanks (6 gal.) I dont realy know what the difference in the tanks would be. Seems like it would be a pain in the *** to remove...
  17. rcl700

    Battery setup questions 24v & 12

    I have a pontoon boat with twin electric drive trolling motors that run on 24v. I have a few questions about the way I have wired everything up. I have drawn a pic of what I have going on. Is this setup correct? if I run my outboard from the same batt. as my console will bath batteries be...
  18. rcl700

    Hole in dust caps?

    Any idea why someone would poke holes in the dust caps? In looking at my tires on the boat trailer today I saw that all four of the dust caps had a hole in them like a punched by a nail. I'm not sure why the previous owner would do this bus it seems to my like it could be a problem. Water and...
  19. rcl700

    TLDI. Beeping every 10 min

    I just bolted up my motor to the transom today and ran the trim up and down. I did not start the motor or even put the key in but every few min. it would beep I think three times. Is this ok? What does that mean? I have to unhook the battery to shut it up while working on the boat. 2004 90b...
  20. rcl700

    diy battery cables

    Where can I buy wire by the foot to make some battery cables? I looked at lowes and the wire they have is not flexable (stiff) any ideas?
Top