Search results

  1. B

    Grease fitting on engine and steering

    Is it okay to use wheel bearing grease to grease the engine fitting and the steering slider? If not what is the correct grease?
  2. B

    Battery for 90HP Engine

    What is good starting battery for a 90HP engine for the money?
  3. B

    2005 90 HP Starting Problem

    I have 2005 90 HP Johnson that won't start. It turns over but won't start. Dealer says it is the encoder. How does the encoder work with these engines? I believe it controls the firing timing but not sure exactly how. Why would it go bad with less than 50 hours on it?
  4. B

    2005 Johnson 90 HP Starting Problem

    I recently purchased a 2005 Johnson 90HP with about 50 hours on it according to the dealer. Problem is that it would not start on arrival. Brought back to dealer and he says it is small gear between the starter pinion gear and the flywheel gear. He says this is broken. Anyone know anything about...
  5. B

    2005 90 HP Evinrude Starting Problem

    My 2005 90-HP has been at the dealer for over a month. He ordered a starter and finally put it in. Now says not the starter but there is small gear in between the starter pinion and the flywheel. He says this gear has a broken tooth. Does this make sense? I have an older 90 HP Evinrude and there...
  6. B

    Fogging engine for winter

    I just bought a 2005 90 Hp Johnson. I've been told two different approaches after adding stabilizer and would like to know which approach is correct. Approach 1. Shut off the gas to run gas out. Then fog the engine through carbs and run until engine stalls. Then pull out plugs and spray fogging...
  7. B

    Gas Sender Unit for 1993 Sunbird 17'

    I need to replace the sender unit in my 1993 Sunbird. Where can I get a replacement for it? How do I get the correct replacement part number (mounting screw pattern, diameter, length, etc.)?
  8. B

    Gas gage always shows empty

    How can I test the sender? Are these sender units universal? Can they be repaired? My boat is a 1993 Sunbird and they have not be made for years.
  9. B

    gas gage problem

    I have a 1993 Sunbird 170. The gas gage reads empty even with a full take of gas. How can I test the sender? How do I remove it? Do I need to try and find the original or are these universal?
  10. B

    Evinrude 1993 90 HP starter bendix spring

    Starter just spins and does not engage with flywheel. I applied WD40 but it is still frozen (won't lift up). Tried to remove the starter to replace the whole thing but starter top upper bolt interferes with carb/air intake. Terrible design. Any suggestions?
View older results
Top