Search results

  1. F

    1993 60 evinrude missing above 3000 rpm once warm

    Hello all. Recently have an issue I thought I would run past everyone. 1993 evinrude 60 starts and run fine until it’s warm. Pulling away from the ramp it accelerates like normal and gets on plane etc. once on plane it starts cutting out. Sometimes it “catches” and picks up where it left...
  2. F

    Stereo system suggestions?

    Hello all . Current setup is 4 speakers, 2 tower speakers and a sub running off of a clarion 5 channel amp. While the sound is decent if you get above halfway on volume there is just not enough power. I’m considering taking the bow speakers off of the amplifier and running those off of the...
  3. F

    1993 Evinrude 60 high speed intermittent miss and other shenanigans

    Hello all just wanted to post here and see if I’m on the right track. Engine has the original VRO pump which has been converted to premix. So my motor gets up on plane fine and runs like normal for about 3-5 minutes. After that there is an intermittent “cutting in and out” while underway. Not...
  4. F

    Power steering fluid leak

    Hello all. I have finally tracked down a vanishing power fluid issue. After feeling around the oil cooler it was soaked with power steering fluid. Seems to be leaking from the actual unit itself and not a hose connection (they were all dry). Engine is a VP 4.3GL and my engine access is...
  5. F

    1999 Volvo penta 4.3 gl starter issue

    Hello all. Well I have ran into something that has me stumped. Last weekend went to crank the engine and could just hear the starter spinning and not engaging the flywheel. I had recently purchased a new starter so new one out of the box, put it in and still having the same issue. The starter...
  6. F

    Blowing 50 amp breaker

    Hello everyone. 1999 Volvo Penta 4.3 GL engine. Was charging my battery this evening before I start troubleshooting a slow crank issue. I switched batteries this afternoon before charging (a known good battery). I get home this evening and attempt to crank it a few times. After doing that...
  7. F

    1999 Volvo penta (possible used boat purchase)

    Hello all. First off I am a bass boat guy and inboard/outboards are out of my wheel house. I am looking at a boat for the family and everything looks good on it but the only thing that concerns me is the boat sat in a slip all last summer and is heavily covered in algae. My question is how on...
  8. F

    1993 60 hp Evinrude chasing an electrical gremlin

    Hi guys. So my boat has sat for 2 years, i am currently in the process of checking everything out and getting it ready for thn water. I go to check spark and i have no spark on all 3 cylinders. I have a service manual and will be following all of the trouble shooting tips there but i do have...
  9. F

    1992 60hp evinrude ignition switch and lost keys!

    Hello everyone. I have misplaced my boat keys and cannot find them anywhere. I have been looking at the switch and cannot find a key code anywhere on it. In the picture is the only markings i can find. There is a J2 stamped on it which is upside down in the picture and scratched into the...
  10. F

    What size set screw for throttle handle

    hello all. In the process of changing my throttle and shift cables, my set screw on the throttle handle decided to jump from its home and to never be seen again lol. Can anyone help with what size that screw is? It is an omc concealed side mount remote control. Thanks in advice everyone!
  11. F

    1993 evinrude throttle lever removal

    Hello all. I need to replace my shift cable and am in the process of removing the throttle lever to get to everything. I have the lever off but I see no way to get the guts out of the inside. There is just not a hole big enough. Any tips would be greatly appreciated
  12. F

    60 evinrude throttle will not go back to idle

    Hi guys I have a 1993 60 evinrude. Just recently rebuilt the carbs, put them back on and now when I advance the throttle and bring it back to neutral the little rubber roller on the middle carb does not come all the way back to where it starts. I can move it back by hand and then all all is...
  13. F

    Removing lower unit 1993 evinrude 60

    Hello all I am having a devil of a time removing my lower unit for a water pump rebuild. I have removed all 4 bolts and the three underneath as well so that makes 7 bolts out. I have disconnected the pin on the right side if the motor and pushed it inward, still won't budge. Where else do I...
  14. F

    Removing lower unit 1993 evinrude 60

    Hello all I am having a devil of a time removing my lower unit for a water pump rebuild. I have removed all 4 bolts and the three underneath as well so that makes 7 bolts out. I have disconnected the pin on the right side if the motor and pushed it inward, still won't budge. Where else do I...
  15. F

    Removing lower unit 1993 evinrude 60

    Hello all I am stumped on removing my lower unit on my 60 evinrude. I have a weak tell tale and am looking to drop the lower unit and service the water pump. I have removed all four bolts and there was one under the cavitation plate I removed as well. I know there is a bolt I need to remove...
  16. F

    1993 60 help!!!!

    Hello all. I had posted previously about my no spark issue with my 60 evinrude. I finally had to take it in to a mechanic. He checked stator, rectifier, timer base, and pack. Turns out the pack is bad. I get a new one and STILL no spark and engine will not fire. Compression is good. Tried...
  17. F

    1993 evinrude 60 fuel pump problems?

    Gentleman. I originally thought I had an electrical issue with my motor starting intermittently. Every once in awhile it will sputter and seem like it is going to fire. Today I decided to hold the key a little longer and presto she fired. Runs like crap and I have to keep choking it for it...
  18. F

    1993 60 evinrude intermittent spark issues

    Hello all. This is update to a previous thread about spark issues with my 93 60hp evinrude. I pulled the black yellow wire and she fired right up. Didn't think anything more about it as it got old and no thoughts of fishing were in y mind. This past weekend started fine although I did notice...
  19. F

    1992 60 evinrude no spark update

    hello all. here is the latest update on my no spark issue. now the darn thing runs like banshee lol. went home at lunch and tried all of my readings again. the black yellow wire was pulled from its connector for some reason at the power pack. i hit the key and presto she fired right up...
  20. F

    1992 60 evinrude has no spark on all three cylinders

    Hi everyone, my cantankerous evinrude has now lost spark on all three cylinders. Started fine a couple of days ago now it cranks but no fire. Spark was tested with inline spark tester. I had this problem before and I disconnected kill switch wiring on the steering wheel side of boat. This...
Top