Search results

  1. P

    Spun Prop on 115 suzuki115

    Thank you for your suggestions. I will mark the prop and test.
  2. P

    DF115 flushing question

    I have a 2005 Suzuki DF115 that I am flushing using the hose Input on the side of the housing. I have been using this since last year while I was working on fuel problems. Today I put the boat in the water and nothing came out the telltale.I ran it for about 15 minutes and it went into limp...
  3. P

    04 Suzuki DF 115 Idle problem

    The fuel system had bad gas so I changed all filters and fuel lines, cleaned the VCM HP fuel pump, Pressure regulator, filter screen checked all sensors all have correct voltage/ohms. The Closed Throttle Position SWITCH is not responding to voltage ( Open circuit ) and I can't find a...
  4. P

    Spun Prop on 115 suzuki115

    This might be a stupid question but I'm going to ask it anyway. Our 18' Flats boat w/ 115 Suzuki has been running great until a couple of days ago. It runs fine up to 2k RPM when you go any faster it over revs. OK First thought is that I spun the hub. When I took off the prop everything looked...
  5. P

    1998 Merc 200 offshore Trim Tilt question

    I have been searching the threads and can't find the answer. What is the proper procedure for cleaning out the old TT oil and replaceing it with new oil, then bleeding the system? The manual I have isn't clear and I don't know what screws are for what. also what is the correct oil for the TT...
  6. P

    Suzuki 115 4 stroke feels like not enough fuel under load @ over 2000 rpm

    I have a problem with the engine sputtering and backfiring at about 2k RPM and higher. This started happening after the boat sat for about 3 weeks. We got about 10 gallons of gas with e10 from the station on the way to the ramp. When we started it up and idled it around for about 10 minutes so...
  7. P

    115 Suzuki Wiring Problem

    My '06 115 is having electrical problems ( sometimes the key is dead in all positions randomly ) I have traced the wiring through all of the wires from the key switch. I think that the problem is in the white wire on the switch. It has a connector 4" from the switch that goes to another white...
  8. P

    2006 Suzuki 115 wiring problem

    I'm trying to figure the wiring of the 115 suzuki I now have the Main Red tag Wire to the Battery Positive. There are 2 other red wires 1 is abt 8Guage and the other is about 10Guage going to the harness under the floor with them both connected to the battery. I have 3 Heavy negative wires, 1...
Top