Recent content by Jose67

  1. Jose67

    Reed/Leaf Valves

    That would be correct, this motor does not have the quick disconnect.
  2. Jose67

    Reed/Leaf Valves

    I do trailer the boat with motor tilted up slightly and fuel in the bowls. I haven't tried the squeezing of the bulb and checking for leaks yet.
  3. Jose67

    Reed/Leaf Valves

    Do not see anything leaking from under flywheel.
  4. Jose67

    Reed/Leaf Valves

    2000 model Johnson 150hp / J150vxsss
  5. Jose67

    Reed/Leaf Valves

    Can faulty reed/leaf valves cause the fuel/oil mixture to seep out of the carbs? Could an overheated engine have caused damage to the valves? After a day on the water I have traces of the fuel/oil mixture seeping down from the lower engine cowl cover onto the mid section. I have checked hoses...
  6. Jose67

    2000 Johnson 150 hp Port side temp switch

    I'm in the Houston-Galveston area.
  7. Jose67

    2000 Johnson 150 hp Port side temp switch

    Thanks for the info.
  8. Jose67

    2000 Johnson 150 hp Port side temp switch

    This may have been answered in my previous post but I was unclear on procedure. My port side temp switch (2 wire) is bad and it is no longer available for purchase. Can it be replaced with a one wire switch and if so what is the procedure? Thanks in advance.
  9. Jose67

    Temperature switch circuit 2000 Johnson 150hp

    Pulse limiter looks clean inside, vapor pump looks good externally but may have to disassemble to inspect it internally.
  10. Jose67

    Temperature switch circuit 2000 Johnson 150hp

    I performed the fuel pump test per the Johnson service manual 3 times, results say air motor diaphragm and/or vacuum rectifier leaking- replace air motor diaphragm. Would this be just a rebuild kit for the fuel pump? Also the two wire temp sensor seems to bad, "hot" light displays when key is...
  11. Jose67

    Temperature switch circuit 2000 Johnson 150hp

    Since the two wire sensor is no longer available, to replace it with a one wire sensor do I tie the 2 wires coming from the harness together and connect to 1 wire coming from sensor?
  12. Jose67

    Temperature switch circuit 2000 Johnson 150hp

    I am sure it is a worn impeller as the stream from pee hole is weak at low rpm.
  13. Jose67

    Temperature switch circuit 2000 Johnson 150hp

    I checked fuel pressure on this engine a couple years ago and it had about 5psi. If my compression readings are indeed low at 92-94psi would this not be enough to pulse the fuel pump causing it not to pump fuel? In addition to checking the fuel pressure I also removed drain plug on 2 carbs and...
  14. Jose67

    Temperature switch circuit 2000 Johnson 150hp

    It shows hot on the system check gauge, I can unplug the two wire sensor and goes away. Something definitely happened to the fuel system when it overheated, I can manually choke it pump primer bulb until I get fuel into the manifolds and it starts fine but I have no fuel pressure ( verified by a...
  15. Jose67

    Temperature switch circuit 2000 Johnson 150hp

    J150vxsss.
See more
Top