Search results

  1. legalfee

    Suzuki DF115B

    I just repowered my pontoon with this motor and I'm looking for a wiring diagram. I would like to wire my fuel and battery gauges to ignition +12. I've also have seen Suzuki has gauges (I do have the Suzuki tach with 4 lights) and am wondering if theirs would be plug and play.
  2. legalfee

    1995 90 HP

    is reading 25 on cylinder one. A sad day but I think I'll retire her and repower with a four stroke.
  3. legalfee

    Motor dies then won't start

    1995 90hp had carbs rebuilt. Ran fine for two hours. Next time out after 30 minutes dies and won't restart. Started fine the next day. I thought it was water in the gas so I installed a water separator. Took the boat out yesterday it dies after 30 minutes and won't restart.
  4. legalfee

    Best water separator

    I just got stranded because of water in my gas and want to put in a water separator. What is the best model to use? Do I still need to keep the plastic filter between the pump and carbs?
  5. legalfee

    Sun Deck / Pop Up changing room.

    Does anyone make these? I would like to change out my sun deck on the port and put in one of these.
  6. legalfee

    Motor stalls in neutral

    Hi all, My 1995 90hp stalls in neutral since I have changed my fuel filter. Also the primer bulb no longer gets firm. I assume I'm getting air the the fuel lines which is what I'll check before messing with the idle speed.
  7. legalfee

    Water in Fuel Starting Issues

    I ran my 95 90hp low on gas and it shut off. I had to use starting fluid to get it going again. I assume it was water in the bottom of the tank. I put some Heet in the tank and 10 gallons of pre mix. Now the motor is very hard to start. It's almost like fuel is not getting to the carbs. My...
  8. legalfee

    Hummingbird Helix 5 CHIRP GPS G3

    According to the manual press menu twice and I should see an Alarms tab. I don't see one. I would like to set a depth alarm. What am I missing? Thanks
  9. legalfee

    Adjusting Trim Tab

    I've got a 1996 90hp that pulls hard to the right. I've read adjusting the trim tab can help this. How do I go about it? Thanks!
  10. legalfee

    Repairing Plexiglass Windshield

    When I removed my windshield from the helm it broke in half. I could not find a replacement so I'm thinking of trying to glue it. From what I've read Weld-On 4 would do the job and I would think I'd need two clamps. Has anyone had any experience doing this?
  11. legalfee

    Best Pontoon Port a John / Changing Room

    What are you guys using? I'm thinking about getting a canvas changing room and port a john.
  12. legalfee

    Fence Panels

    How hard is it to replace fence panels? Should I get ,020 or .030? My panels are 20" so I guess I'd have to cut them.
  13. legalfee

    RPM surge at WOT

    I recently got my 95 Sylvan 824e pontoons cleaned, drained, patched, and pressure tested. The boat went from 5600 RPMs WOT at 18 MPH to almost 6000 RPMs and 22.5 MPH. Running at 5500 RPMs in 6" chop I noticed the boat would run at 5500 for 4 or 5 seconds then surge to 5600 for a second then back...
  14. legalfee

    1995 Force 90hp bad switchbox

    This weekend I started up my boat and it would not idle and WOT was only 4500. To make a long story short I was not getting spark on the number one cylinder. There had been multiple times when placing the cowl I have knocked off the top coil wire. I have read here that running the motor with the...
  15. legalfee

    Repowering 1995 Sylvan Marine 24ES4 824 Special Edition

    I have a 1995 Sylvan with a 90hp Force 2 stroke. I'm considering repowering with a Mercury 4 stroke. My Force weighs 280 lbs. Thee Mercury 60hp weighs 247 and the 90hp 359. Should I go with the lower weight 60? My boats tilts somewhat with the Force what would it do with an additional 80 lbs...
  16. legalfee

    Quicksilver Black Diamond QA2034X

    I finally installed a new prop on my 1995 90hp Force. Went from 13p 6000 at WOT to 15p 5600. Big difference I should have done this a long time ago.
  17. legalfee

    Speedometer Tube

    I have a 1995 Force 90HP. My speedometer doesn't work and the tube looks like it's going into the lower unit. Is there a hole down there that is possibly clogged and can be cleaned out?
  18. legalfee

    Stern Ladder

    I finally got my new stern ladder installed. So much better than the detachable gate ladder.
  19. legalfee

    Python Rope Cinch

    Anyone use some of these?
  20. legalfee

    Water Leaks

    I have a 1995 Force 90HP. When I cranked it up today I noticed water coming out of the bottom of the cowl assembly on both sides. Is this something I should be concerned about?
Top