Search results

  1. A

    2003 Johnson 90HP V4 J90PLSTC Cable?

    Hello again, I recently had to purchase a new shifter cable. I think it is adjusted correctly however, I am not sure. Does anyone know the correct procedures from the manual on installation of the shifter and throttle cables? Thanks again Andy
  2. A

    2005 Johnson 15Hp lower unit ?

    2005 Johnson 15HP lower unit on a 2 stroke model the same as a 4 stroke model? I want to get a longer shaft and there is one on ebay but it is for a 4 stroke and mine is a two stroke. if they are different can I remove parts off my shorter shaft and parts off the 4 stroke to make it work...
  3. A

    2006 15hp johnson controls ?

    Hello, I have a 2006 Johnson 15hp pull start tiller. this is not power trim. I would just need fwd,rev, throttle and kill switch. I will be hooking it to my 90hp for turning. The question is I would like to put controls on it instead of tiller. I am having trouble finding the control I would...
  4. A

    Fuel consumption Johnson 15 Hp (j15rsdr)

    Does anyone know how much fuel this engine would burn under "normal" operation conditions lets say half throttle most of the time? Reason why is I want to buy a fuel tank for it but don't know what size to buy. 3 gal 5gal 6gal? I like the 3 gal because it fits in a little spot at the back of...
  5. A

    fuel mix question?

    Hello Again, I have two motors (main and kicker) 1) 2002 Johnson 90hp j90plstc 2) 2006 Johnson 15hp J15rsdr Can anyone please help me with what the fuel mix ratio is for both of these motors? ps. I want to run both motors from the onboard fuel tank. The 90Hp has direct inject ( I am going to...
  6. A

    2 part question here? 2006 Johnson 15HP

    Hello again, I have recently purchased a 2006 Johnson 15HP (J15RSDR) Q 1. Can I remove the tiller and shifter and purchase control cables? Q 2. Can I purchase a electric starter, Wire harness and ignition switch? Thanks for any help.
  7. A

    2003 j90plstc won't stay running at low idel into gear

    2003 Johnson 90Hp j90plstc 2 stroke (V4) My engine started something new? The engine will not run correctly at low idle. once warmed up runs kinda okay but when just starting it stalls a lot until I prime the bulb. it gets really bad when I shift into gear it boggs and then stalls only at low...
  8. A

    Johnson Repair manual

    Does anyone know where I can get a 2003 Johnson repair manual for cheap? j90plstc 2 stroke? Thanks
  9. A

    HELP!!!! 2003 Johnson 90 hp

    2003 Johnson 90hp v4 lower unit removal got all the bolts just cant figure out the shifter rod disconnection how to get it off to remove the lower unit for prop shaft replacement thanks andy
  10. A

    Wiring 2003 Johnson 90 hp

    Ok well I have asked a couple of times here about this. On top of the motor there is a cover. It is covering up wiring that is yellow with grayish line. I have been told it is the tach however, I pulled apart my boat today and all the wires going to the tach are plugged in. And none of them are...
  11. A

    Johnson 90hp rectifier help

    Ok he is my question 2003 Johnson 90HP (J90PLSTC) is on a 2003 Crestliner Superhawk 1) What does the rectifier do? I understand that it makes DC into AC but why would you want to do that on a boat? 2) There is a wire coming from it, that is yellow/grey in color. Any Idea on where it goes it has...
  12. A

    2003 Johnson 90hp 2 Stroke

    I just bought a 2003 Crestliner superhawk 1700 with a Johnson 90hp 2 Stroke I had to fix some wiring, The isolator bank for charging two batteries is broken and there is a wire coming from the top of the engine near the back that is yellow and silver in color. I metered it and it is showin 7.2...
  13. A

    1982 9.8 HP Won't top out

    Hello, I have a 1982 Mercury 9.8 HP. I replaced the impeller when I bought the motor from a friend. He had it on a 18ft pontoon and he said it never really went over 4 or 5 mph. So I thought I could put it on my 1968 astroglass (boat weight is about 400lbs I am 250lbs so with gear it is about...
  14. A

    2004 Crestliner Sportfish 1750 Gas tank cleaning

    Hello, I have recently purchased a 2004 Crestliner Sportfish 1750 from my father who bought the boat new in 2003. I will be picking up the boat next month from his house In Michigan. He never used the boat much so it has low hours. He said the boat has been in the garage for 3 years now and...
  15. A

    tiller steering behind wheel

    Does anyone have a diagram or something to show how the wire rope should be on the goofy looking round thing behind the steering wheel. all my pulleys broke and caused the rope to jump off the goofy looking round thing behind the steering wheel. the goofy looking round thing behind the steering...
  16. A

    1968 Johnson 40 HP Electramatic repair manual?

    Does anyone own a 1968 Johnson Repair manual that would be willing to share info? Thanks Andy
  17. A

    1968 Johnson 40 HP idles but bogs out at 1/2 to 3/4 throttle?

    Hello, I have a 1968 Johnson 40 HP - Model # RKL-30A Electramatic Shift. This motor has been sitting since 2003. However, I have pulled apart and cleaned everything for the most part (carburetor, lower end, Ect.). The issue I am having is this: when you pull the start lever the engine fires...
Top