Recent content by bbrad99

  1. B

    What is my pontoon worth

    I have a 94 Aqua Patio Pontoon with a 94 Mercury 40 HP outboard. I'm thinking about selling it locally and wondered what the boat is worth due to some issues I have with it. I looked on NADA and it says its worth 6K. Seems high. Breakdown: Tandem 24' trailer $865, Motor $720, Boat with bimi...
  2. B

    Max Temp for Mercury 40 HP (Overheat Alarm Issue)

    I have been battling an overheat alarm issue when I push my engine up close to 5000 RPMS. Boat runs fine lower RPMS. Once alarm goes off, I throttle down and it turns off after about 10 seconds. I can recreate the alarm anytime I get up close to 5000 RPMS. Had impeller replaced twice by...
  3. B

    Help with temperature sender for Mecury 40 HP

    I have inherited a Pontoon boat with a 1994 Mercury 40 HP 4 Cyl 2 Stroke. Serial 0G038000. If I exceed 4200 RPM's I get a steady overheat alarm. Stays on until I slow down and then it shuts off after about 10 seconds or so. I have changed the water impeller twice. I'm now looking at the...
  4. B

    Can't fnd thermostadt on this 40 HP Merc

    94 Mercury 40 HP Serial 0G038000 Model 1040412PD It must be tough to replace as I can' t seem to find it.
  5. B

    Water Pressure Gauge Kit for Mercury 40 HP

    Trying to troubleshoot an overhearing issue with my Merc. Want to install a water pressure gauge but having a hard time locating a kit to do so. Is there a complete kit out there or do you have to peice this thing together. I'm new to boating so I'm learning. Replaced water pump. Might...
  6. B

    Looking for corner cap for my 94 Aqua Patio

    I have one broken corner cap. Does anyone know where I can get a replacement or ones to fit my toon? See pictures below of damaged one and a good one. Thought about replacing them all but I can't find any that mount like these do. I'm a new pontoon owner so I'm still learning.
  7. B

    Mercury 40 HP Outboard overheating alarm over 4000 rpms on 24' Aqua Patio Pontoon

    I inherited a 1994 24' Aqua Patio Pontoon boat from my father. The boat runs fine going slow to medium throttle. When I go full throttle or anything past 4200 rpms, after about 30 seconds I get a constant beep that won't stop unless I bring the throttle back down to idle or very slow...
See more
Top