• If this is your first visit to the iboats.com Boating Forums, be sure to check out the FAQ. To post a question or comment, begin by signing up. To start viewing messages, select the forum that you want to visit from the selection below.



Help Tip: If you have a question that has not been answered to your satisfaction in the archives, it is always best to start a new thread of your own. By starting your own thread, you will receive the maximum number of views by forum members.

Below are some additional forum policies in hopes of all iboats members will follow, Thank you.

1. Please do not reply to old topics or hijack existing topics. Old topics of a technical nature are like a library book, Please do not write in them.

2. Old topics should be considered archives and used for reference only. Please do not reply to them.

3. Do not take over someone elseís topic (aka hijack) with your own question, even if it is similar. If you have a question that has not been covered to your satisfaction in the archives, it is always best to start a new topic of your own.

4. If you have a question for the original poster (OP) and the topic is over 30 days old, send the OP a PM, he may not even visit the forums any longer, or may not notice your question in the old topic.

5. By starting your own topic, you will receive the maximum number of views by forum helpers that may not even notice your question when itís posted at the end of someone elseís topic. And those answers will be specific to your particular issue.

6. Please do not post to topics that have been inactive for more than 3 months unless you are the original poster. We have very active forums and any topic that remains inactive for that long should be considered "dead". It is especially confusing when there is an entirely new question posted to an old topic.

7. Posting at the end of any topic is considered to be hijacking the original posters topic which in turn subjects the topic to be closed if it continues to happen thus not making it fair to the original poster in the future had for some reason he/she needed to return for additional information or provide an update of the problem solved which is always welcomed within a reasonable amount of time frame.

8. Please note that you should see a red banner pop up near the bottom of each inactive topic asking you not to reply to old topics. The Red banner will read: Please note this topic has been inactive for 90 days. For the best results, please start a new topic.

Thank you all in advance for doing your part in helping iboats run a smooth ship.

Additional forum rules linked below.
See more
See less

Suzuki DF6 - self service for dummy

  • Filter
  • Time
  • Show
Clear All
new posts

  • Suzuki DF6 - self service for dummy

    I am not a service technician and am amazed at some of the stuff you guys do with your motors. But ...

    I have a Suzie DT6 (2006) which is overdue for a service. If I follow the manual and do an annual maintenance schedule (replace plug, engine and gear oil, lubricate and check fuel line) is this enough to keep the motor healthy or do the "experts" do lots extra to prolong the life and keep the motor running reliably?

    The manual recommends replacing the impeller but does not give instructions on how this is done.

    Anyone care to comment?

  • #2
    Re: Suzuki DF6 - self service for dummy

    i have the samotor i bought last spring, and it ran great . this spring ....not so good it starts fine idles fine but bogs out when i give it gas.....ive replaced the fuel filter and when i block the air intake with my finger it will run good?????cleaned the carb replaced the oil checked the plug ....what else is there?????i like this motor but i fear it a piece of crap...what do you think of yours??


    • #3
      Re: Suzuki DF6 - self service for dummy

      My DT6 of 2003 vintage is a sweetheart. Problems with these motors are few and far between and usually, as in most cases, something simple. Remember most of the problems are fuel related. Thanks to all the new rules fuel left sitting without a preserving additive will probably be sour in 60 days.


      • #4
        Sign up today
        Re: Suzuki DF6 - self service for dummy

        Sorry, I should have refered to my DF6 not DT6.